Product ID:INDUSTRIAL ENAMELS-USDA APPROVED TOPCOAT
MSDS Date:01/03/1990
FSC:8010
NIIN:00-616-7486
MSDS Number: BKPJF

Emergency Phone: 708-367-7700

Info Phone: 708-367-7700

Cage: 08882

Telephone: 847-367-7700

Cage: 08882

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 30-55%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:INHALATION: HARMFUL IF INHALED. MAY
AFFECT THE BRAIN & NERVOUS SYSTEM CAUSING DIZZINESS, HEADACHE &
NAUSEA. REPEATED OVEREXPOSURES MAY LEAD PROGRESSIVELY TO STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA. CAUSES NOSE & THROAT
IRRITATION. SKIN OR EYE CONTACT: CAUSES EYE AND SKIN IRRITATION
WHICH CAN LEAD TO *
Effects of Overexposure:*DERMATITIS WITH REPEATED OVEREXPOSURES.
INGESTION: GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING &
DIARRHEA. CHRONIC: REPORTS HAVE SHOWN REPEATED & PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WIT H PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE.

First Aid:INHALATION: REMOVE FROM EXPOSURE, RESTORE BREATHING & NOTIFY
PHYSICIAN. EYE: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER-15 MIN.
NOTIFY PHYSICIAN. SKIN: WASH AFFECTED AREA W/SOAP & WATER, REMOVE
CONTAM INATED CLOTHING & WASH BEFORE REUSE. INGESTION: DO NOT
INDUCE VOMITING. KEEP WARM & QUIET. GET MEDICAL ATTENTION.
ASPIRATION OF MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.

Flash Point Method:TCC
Flash Point:104F,40C
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CARBON DIOXIDE, DRY
CHEMICAL OR FOAM).
Fire Fighting Procedures:USE FULL PROTECT EQUIP, INCLUD SCBA. WATER
SPRAY INEFFECT. COOL CLOSED CONTAINERS W/WATER-PREVENT PRESS
BUILD-UP/AUTOIGNITE/EXPLOS. WATER USED/FOG NOZZ PREFER.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. KEEP FROM
IGNITION SOURCES. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. DO NOT APPLY TO HOT SURFACES.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
& REMOVE WITH INERT ABSORBENT AND NONSPARKING TOOLS.

Handling and Storage Precautions:DO NOT STORE ABOVE 120 F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED & PROTECTED FOR STORAGE OF NFPA
CLASS II COMBUSTIBLE LIQUIDS.
Other Precautions:CONTAINERS SHOULD BE GROUNDED WHEN POURING. EMPTY
CONTAINERS MAY BE HAZARDOUS.

Respiratory Protection:USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR
TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY AND ORGANIC VAPORS
DURING SPRAY APPLICATION. IN CONFINED AREAS: USE NIOSH APPROVED
SUPPLIED-AIR RESPIRA TORS OR HOODS.
Ventilation:PROVIDE GENERAL DILUTION OR LOCAL EXHAUST VENT IN VOLUME &
PATTERN TO KEEP TLV OF HAZARDOUS INGRED BELOW ACCEPTABLE TLV.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:SAFETY EYEWEAR.
Other Protective Equipment:USE CLOTHING TO PREVENT PROLONGED SKIN
CONTACT.
Supplemental Safety and Health

HCC:F4
Boiling Pt:B.P. Text:307 TO 389F
Vapor Density:> AIR
pH:NA
Evaporation Rate & Reference:SLOWER (ETHER = 1)
Percent Volatiles by Volume:51-66

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:BY OPEN FLAME-CARBON MONOXIDE AND
CARBON DIOXIDE.

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.